50Hz AC Three Phase Synchronous Brushless Diesel Generator 400kw 500kVA

Model NO.: HGM550 Installation Method: Fixed Cooling Method: Water Cooling Speed: Speed Usage: Common Units Excitation Mode: AC Rotating Exciter Alternator Model: Meccalte Eco40-3s/4 Voltages: Low Voltage 380V , 400V ,Adjustable Warranty: 1 Year or 1000hours Canopy Types: Silent ,Container,Trailer ,etc Weight: 3410kg Specification: ISO8528 HS Code: 8502131000 Type: Self-Starting diesel generator Stroke: Four Stroke Output Type: AC Three Phase Conditions of Use: Land Use Landuse Type of Unit: Low Noise Engine Model: Googol Ptaa890 Controller Model: Deep Sea, Comp, Datakom , etc Certificates: CE,ISO.BV,GOST,Tus,SGS Prime Power: 400kw/500kVA Option: ATS,Circuit Breaker,Panels Trademark: HONNY Origin: Guangdong, China 50Hz AC Three Phase Synchronous Brushless Diesel Generator 400kW 500kVA

Features:
Honny Power provides one-source responsibility for the generating system and accessories.
The Generator Set and its components are prototype-tested, factory-built, and production-tested.
The generator set accepts rated load in one step.
A one-year limited warranty covers all systems and components. Two-, five-, and ten-year extended warranties are also available.

Alternator features:
The pilot-excited, permanent-magnet (PM) alternator provides superior short-circuit capability.
The brushless, rotating-field alternator has broad range reconnectability.
NEMA MG1, IEEE, and ANSI standards compliance for temperature rise and motor starting.
Sustained short-circuit current of up to 300% of the rated current for up to 10 seconds.
Sustained short-circuit current enabling down stream circuit breakers to trip without collapsing the alternator field.
Self-ventilated and drip-proof construction.
Superior voltage waveform from a two-thirds pitch stator and skewed rotor.
Digital solid-state, volts-per-hertz voltage regulator with around 0.25% no-load to full-load regulation.
Brushless alternator with brushless pilot exciter for excellent load response.

Other Features:
Controllers are available for all applications.
The low coolant level shutdown prevents overheating (standard on radiator models only).
Integral vibration isolation eliminates the need for under-unit vibration spring isolators.
An electronic, isochronous governor delivers precise frequency regulation.
Multiple circuit breaker configurations.
Standard Supply:

Common steel base frame, Damper, Exhaust silencer, Flexible pipe, Battery and connecting wires, Operation manual and document.

Optional Accessories:

Engine coolant and oil heater, Alternator space heater, Cooling for heat exchanger, Control system with RS232/485 communication interface, Battery charger by main supply, Fuel-water separator, Daily fuel tank, ATS & Paralleling System, and Moving Trailer.

Packaging& Shipping
1, Plastic film package, depends on Client's requirement
2, 35days after First Payment, Accept FOB, CIF, EXW, etc

Generator Model		HGM550
Genset Prime Power		400kW/500kVA
Engine Ratings:
Engine Speed	(RPM)	1500
Generator set Frequency	(Hz)	50
Engine Standby Power (LTP)	(kW)	491
Engine Prime Power (PRP)	(kW)	448
Engine Continuous Power (COP)	(kW)	341
Single Fan Power	(kW)	20
Single Fan Consumption	(kW)	20
Quantity of Fan	(Sets)	1
All Fan Consumption	(kW)	20
Engine Net Standby Output  (LTP)	(kW)	471
Engine Net Prime Output  (PRP)	(kW)	428
Engine Net Continuous Output  (COP)	(kW)	321
BMEP for Standby Output	(bar)	26.84
BMEP for Prime Output	(bar)	24.48
BMEP for Continuous Output	(bar)	18.68
Typical Generation Standby Output	(kVA)	550
Typical Generation Standby Output	(kW)	440
Typical Generation Prime Output	(kVA)	500
Typical Generation Prime Output	(kW)	400
Typical Generation Continuous Output	(kVA)	375
Typical Generation Continuous Output	(kW)	300
Typical  Alternator Efficiency	≥	93.5%
Power Factor		0.8
Speed droop (static) elect. Gov.		0-5%
Governing standards to ISO 8528 Parts 1 and 5		G3
Max. step load acceptance, 1st step(% Prime Output)		53%
Basic Performance Datasheet
Aspiration Type		Turbocharger, air-air after-cooler
Injection Type		Direct Injection
Configuration		In Line
No. of Cylinders		8
Displacement	(liters)	14.6
Bore	(mm)	128
Stroke	(mm)	142
Compression Ratio		14.6:1
Piston Speed	(m/s)	7.10
Rotation Direction (from flywheel)		Counter Clockwise
Number of Flywheel Teeth		160
Flywheel House Size		SAE1-14
Lubrication System
Lube Oil Specification		AFI-CF4
Oil Capacity	( Liters)	32
Max. Permissible Oil Temperature	(°C)	110
Low Oil Pressure Warning	(kPa)	200
Low Oil Pressure Shutdown	(kPa)	160
Oil consumption (as % of fuel consumption)		≤0.5
Cooling System
Coolant Capacity for Engine	( Liters)	20
Max. Permissible Temperature	(°C)	90
Max. Coolant Warning Temperature	(°C)	95
Max. Coolant Shutdown Temperature	(°C)	105
Thermostat OPEN Temperature	(°C)	71
Radiator Cooling Flow	(m³/min)	574
Flow of Coolant pump	(m³/h)	25.98
Heat dissipation (engine radiator)	(kW)	237
Heat dissipation (convection)	(kW)	36
Radiator Model		PSCN3000
Fuel System
Governor Type			Electrical Control
Engine Output at generator set prime output	(kW)		448
Fuel Consumption at 25% of generator set prime output	(l/h)		33.93
Fuel Consumption at 50% of generator set prime output	(l/h)		59.04
Fuel Consumption at 75% of generator set prime output	(l/h)		84.91
Fuel Consumption at 100% of generator set prime output	(l/h)		113.58
Lowest Fuel Consumption Ratio	g/kW.hr		211.11
Intake & Exhaust System(On Standby Output)
Combustion Air Consumption	(m³/min)		36.79
Max. Intake Restriction	(Kpa)		5
Max. Exhaust Temperature(Before Turbo)	(°C)		675
Max. Exhaust Temperature(After Turbo)	(°C)		430
Max. Exhaust Back Pressure	(Kpa)		5
Exhaust Gas Flow	(m³/min)		44.97
Exhaust Flange Diameter	(mm)		2*100
Electrical System
Charging Alternator Voltage	(V)		28
Charging Alternator Capacity	(A)		55
Starting Voltage	(V)		24
Starting Motor Capacity	(kW)		1*6.6
Minimum Battery Capacity	(Ah)		2*200
Minimum Temperature for Unaided Cold Start	(C)		10
Engine Dimension
Length	(mm)		1484
Width	(mm)		1389
Height	(mm)		1162
Engine Dry Weight w/o Cooling System	(kg)		1125
Note:
1,All engine parameters are in accordance with ISO3046, ISO8528 2,All engine parameters are based on 25°C / 100kPa environment condition 3,No power decrease with below 40ºC environment temperature and 1500 meter altitude 4,More than 40ºCand 1500m above sea level , decrease 2% per 10ºC , and 4% per 300m 5,At calorific value 42700 kJ/kg + 5%, density 0,835 kg/dm3 , temperature 280 K 6,Above data is only the testing data in our laboratory, it can't used to be the data on all contract
Alternator Alternator model MGA355-400-4SF Rating Voltage(V) 400/230V,380/220V adjustable Rating Capacity(KW/KVA) 400/500 Eff.% 95.1% Power Factor 0.8 Exciting type Brushless self-exciter AVR Voltage regulation ±1% No. of  Phase 3 phase 4 wire Enclosure Class IP21 Class of Insulation H   Standard Accessory  Battery 2X200AH 12V Battery Wires 1 set Flexible Pipe 2*6 inch Industry Silencer 2*6 inch Optional Accessory VCB Breaker Panel 800A Fuel Tank 500 Liter Fuel-water Separator  Heater Coolant & Oil Heater Contact us if you need more details on AC Three Phase Generator. We are ready to answer your questions on packaging, logistics, certification or any other aspects about Synchronous Diesel Generator、Brushless Diesel Generator. If these products fail to match your need, please contact us and we would like to provide relevant information. Product Categories : Googol Generators Other Products 200kw Googol Silent Power Generator Set Contact Now Silent Googol Diesel Generator Set 1875kVA 1500kw Contact Now Hgm1675 Googol Generator 1675kVA Contact Now Googol Diesel Silent Automatic Generator 450kVA 360kw Contact Now Hot Products Honny Branded Dual Fuel Generator (diesel fuel, HFO fuel, Nature Gas)30kw-1500kw Googol Natural Gas Biogas Generator Set 50/60Hz1MW-500MW Power Plant with Fuel Diesel Gas Dual Fuel HfoPerkins Diesel Generator Set 1320kw/1650KVAHonny Small Diesel Generator in Stock2500KVA Power Generator, 50Hz, 1500rpmGenerator AVR Voltage Regulator For Generator2inch 3inch 4inch Agricultural Irrigation Faming Water Pump2KW 5.5HP 2.5KW 6.5HP Single Phase AC Generator 220V600W 1KW 2KW 2.5KW 2.8KW 3KW 5KW 6KW 500w Price Mini Generator Silent Mini GeneratorsSmall Jet Car Wash Machines For SaleEY20 Gasoline Engine 5.0HP Engine High Quality small Petrol Engine2Kva DC Price Taizhou Gasoline Generators Prices In Dubai3000W Electric Portable Low Noise 24V DC Generators lOW RPM 3phase With WheelsCE ISO 4-Stroke 2.0KVA 2.5KVA Gasoline Electric Generator Set Specifications For Sale12V DC Portable 2.0HP Mini Petrol Generator For Nigeria The Latest Product Alerts Send Me PRODUCTS Belten Gasoline Generator Belten Gasoline Water Pump Belten Gasoline Engine Belten High Pressure Washer Portable Catalogue Gasoline Generator Gasoline Engine Gasoline Water Pump High Quality Generator Set, Diesel Generating Set, Diesel Generation Set Suppliers in China Copyright © 2024 www.tz-generator.com All rights reserved.